rosy progress report / november 5

There are so, so, SO many things to pull out of an Airstream in order to get to the subfloor.

The plan for today was to loosen or remove everything in the way of the floor. That means the fresh water tank, water pump, furnace, on-demand water heater, and the toilet. In the three-ish hours we were there, I pulled out the fresh tank, and Vick handled the furnace, and then both of us pulled out the ductwork. Because if you’re going to pull out the furnace, you might as well pull out the ductwork too. We aren’t totally sure we’re going to keep the furnace, anyway. It’s older and takes up a ton of valuable storage space. If anyone has any recommendations on space and energy saving alternatives, we are all ears!

removing airstream argosy ductwork

Before pulling ductwork:

removing airstream argosy ductwork

After pulling ductwork:

airstream argosy renovation wheel well

We did have to go primitive with standard hand tools for a bit for some hard to reach screws and bolts on the ductwork. We are so spoiled on power tools!

removing airstream argosy ductwork

I also loosened the on-demand water heater, which was affixed to the floor with a few three inch long screws.

airstream argosy renovation on demand water heater

Once all of that was taken care of, the trailer was an absolute mess, and I didn’t want to proceed any further until we tidied things up a bit.

We swept up as much debris as we could, except for what’s in the little nooks and crannies that are hard to reach – which is why we still have dozens of pop rivet mandrels left behind by Rosy’s previous owner (the little metal rods pictured below). They’ll get swept out eventually.

airstream argosy renovation pop rivet mandrel

Our toolbox desperately needed organizing, so we took care of that as well. We are typically so focused on whatever we’re working on, that once we’re done for the day at our worksite, tools are everywhere. We’re normally leaving the worksite in a rush to get home before Cowboys kickoff, so we usually just gather the tools as fast as we can and dump them wherever they fit in the box. This had gone too far, so I’m glad Arnavick instigated a toolbox organizing sesh – we were overdue.

airstream argosy organizing tools

We also sifted some trash out of our can o’ hardware – can you believe that all of these screws and hose clamps and such came out of our little 27-foot trailer? There are so many of them! And we still have more to go…

airstream argosy organizing tools screws

Suffice to say, after all that cleaning, we didn’t get to cross everything off of our list of items keeping us from getting to the subfloor. BUT, progress is progress, so we’re satisfied with that. We are a tad bit nervous about disconnecting the water pump and surrounding wires. Arnavick thinks some of the wires may be for the DVD/sound system our previous owner installed. To me, it just looks like a bunch of colorful cords. We have a friend that knows electrician things, so hopefully, we can get him out to take a look and give his expert advice.

airstream argosy renovation water pump wires

We also didn’t get the toilet out. We’ve been talking about this for weeks, but have been saving it for last. I feel like it’s best to pull out the ol’ pot just before handling the subfloor, just in case there are some icky fumes or minor biohazard situations that arise. We’ll already have everything else out of the way at that point, so it should minimize the impact of any potential issues.

Now’s a good time for a before and after, don’tcha think?

When we got the trailer:

airstream argosy renovation goucho before

Current status:

airstream argosy renovation goucho progress

Now I feel much better, after seeing what a difference we’ve made in just under three months. After all, we both work full time (and then some), and I go to school and am active in school organizations, which leaves us only one day per week to work on the rig. Progress is progress, right?

So who has hot tips on a space-saving furnace (pun always intended)? Or even full HVAC options? I’d love to get rid of the roof AC unit, too! Advice in the comments – go!

Advertisements